2019-Sustainable Industrial Processing Summit
SIPS2019 Volume 11: New and Advanced Materials, Technologies, and Manufacturing
| Editors: | F. Kongoli, F. Marquis, N. Chikhradze, T. Prikhna |
| Publisher: | Flogen Star OUTREACH |
| Publication Year: | 2019 |
| Pages: | 174 pages |
| ISBN: | 978-1-989820-10-0 |
| ISSN: | 2291-1227 (Metals and Materials Processing in a Clean Environment Series) |
CD shopping page
Oxidative Dehydrogenation of Light Alkanes over Oxide-based Catalysts: Enhancing the Selectivity
Ioan-Cezar Marcu1;1LABORATORY OF CHEMICAL TECHNOLOGY & CATALYSIS, FACULTY OF CHEMISTRY, UNIVERSITY OF BUCHAREST, Bucharest, Romania;
Type of Paper: Keynote
Id Paper: 22
Topic: 43
Abstract:
Oxidative dehydrogenation (ODH) of light alkanes may offer a promising alternative for the production of the corresponding alkenes compared to the simple dehydrogenation. This is because ODH has the advantage of an exothermic reaction without thermodynamic limitations and with a low risk of catalyst deactivation through coking since the reaction is run in an oxidative environment. Nevertheless, the main difficulty in obtaining high alkene yields by ODH of light alkanes arises from the fact that the alkene is more reactive than the corresponding alkane, thus being prone to further oxidation to produce carbon oxides. Indeed, ODH of light alkanes proceeds through sequential (Alkane --> Alkene --> Carbon oxides) and parallel (Alkane --> Carbon oxides) oxidation steps, the secondary reactions, i.e. the deep oxidation of both alkane and alkene, being more thermodynamically favorable than the oxidative dehydrogenation. Consequently, the catalyst should significantly accelerate only the chosen sequence of elementary steps and suppress all other possible elementary steps, parallel or consecutive. Several approaches should be considered to meet this selectivity challenge: (i) using carbon dioxide as soft co-oxidant; (ii) isolation of the active-site; (iii) the decrease of the lattice oxygen reactivity and (iv) increasing the catalyst basicity. All these approaches will be illustrated with relevant examples from our own research work on this subject published in the last decade [1-10].
Keywords:
Energy; New and advanced materials; New and advanced technology; Sustainable development;References:
1. G. Mitran, R. Ahmed, E. Iro, S. Hajimirzaee, S. Hodgson, A. Urda, M. Olea, I.-C. Marcu, Propane oxidative dehydrogenation over VOx/SBA-15 catalysts, Catal. Today 306 (2018) 260-267.2. S.-B. Ivan, I. Popescu, I. Fechete, F. Garin, V. I. Parvulescu, I.-C. Marcu, The effect of phosphorus on the catalytic performance of nickel oxide in ethane oxidative dehydrogenation, Catal. Sci. Technol. 6 (2016) 6953-6964.
3. I. Popescu, Z. Skoufa, E. Heracleous, A.A. Lemonidou, I.-C. Marcu, A study by electrical conductivity measurements of semiconductive and redox properties of Nb-doped NiO catalysts in correlation with the oxidative dehydrogenation of ethane, Phys. Chem. Chem. Phys. 17 (2015) 8138-8147.
4. I. Popescu, E. Heracleous, Z. Skoufa, A.A. Lemonidou, I.-C. Marcu, Study by electrical conductivity measurements of semiconductive and redox properties of M-doped NiO (M = Li, Mg, Al, Ga, Ti, Nb) catalysts for the oxidative dehydrogenation of ethane, Phys. Chem. Chem. Phys. 16 (2014) 4962-4970.
5. I.-T. Trotuş, C. M. Teodorescu, V. I. Parvulescu, I.-C. Marcu, Enhancing oxidative dehydrogenation selectivity of ceria-based catalysts using phosphorus as additive, ChemCatChem 5 (2013) 757-765.
6. G. Mitran, T. Cacciaguerra, S. Loridant, D. Tichit, I.-C. Marcu, Oxidative dehydrogenation of propane over cobalt-containing mixed oxides obtained from LDH precursors, Appl. Catal. A 417-418 (2012) 153-162.
7. S. Tanasoi, G. Mitran, N. Tanchoux, T. Cacciaguerra, F. Fajula, I. Sandulescu, D. Tichit, I.-C. Marcu, Transition metal-containing mixed oxides catalysts derived from LDH precursors for short-chain hydrocarbons oxidation, Appl. Catal. A 395 (2011) 78-86.
8. I.-C. Marcu, M. N. Urlan, A. Redey, I. Sandulescu, Phosphated ceria, selective catalysts for oxidative dehydrogenation of isobutane, C. R. Chim. 13 (2010) 365-371.
9. G. Mitran, A. Urda, N. Tanchoux, F. Fajula, I.-C. Marcu, Propane oxidative dehydrogenation over Ln-Mg-Al-O catalysts (Ln = Ce, Sm, Dy, Yb), Catal. Lett. 131 (2009) 250-257.
10. F. Urlan, I.-C. Marcu, I. Sandulescu, Oxidative dehydrogenation of n-butane over titanium pyrophosphate catalysts in the presence of carbon dioxide, Catal. Commun. 9 (2008) 2403-2406.